PENGARUH PRE-HEATING PADA PIROLISIS BIOMASSA LIMBAH AREN TERHADAP CHAR PADA REAKTOR HORIZONTAL MODEL CONTINUOUS

Roli Russiadi, Herman Saputro, Husin Bugis

Abstract

Utilization of palm waste in the form of charcoal briquettes makes the fuel more efficient and in a better form. Thus, charcoal briquette fuel with sugar palm waste is a solution or alternative to solving the waste problem caused by palm trees. This research was conducted with the aim of knowing the effect of pre-heating on the pyrolysis process of palm sugar waste biomass on gas fraction, bio-oil and char. This study used an experimental method conducted in the Mechanical Engineering Education Laboratory of Sebelas Maret University. The research variable is the variation of pre-heating time in the pyrolysis of palm waste biomass against gas fraction, bio-oil and char in a continuous model horizontal reactor. The result of this study is that pre-heating has an effect on the gas fraction. The longer the pre-heating process is carried out, the lower the amount of O2 gas produced. Pre-heating affects the char, so the quality and quantity can be measured.

Keywords

Pre-heating, pyrolysis of biomass, palm waste, gas fraction, bio-oil, continuous model horizontal char reactor.

Full Text:

PDF

References

Abdullah, M. A. (2021). Improvement of the Pyrolysis System by Integrating Solar Energy Based Preheating System. IOSR Journal of Mechanical and Civil Engineering (IOSR-JMCE), 18(3), 25–30. https://www.iosrjournals.org/iosr-jmce/papers/vol18-issue3/Series-4/D1803042530.pdf

Basu, P. (2010). Biomass Gasification and Pyrolysis: Practical Design and Theory. Academic Press.

Diebold, J. P. (1999). A Review of the Chemical and Physical Mechanisms of the Storage Stability of Fast Pyrolysis Bio-Oils. National Renewable Energy Laboratory. https://www.nrel.gov/docs/fy00osti/27613.pdf

Ependi, D. R. (2019). Studi Eksperimental Dan Numerik Pengaruh Temperatur Udara Inlet Proses Gasifikasi Pelet Msw Terhadap Performansi Multi-Stage Downdraft Gasifier [Institute Teknologi Sepuluh Nopember]. https://repository.its.ac.id/61237/1/02111750020011-Master_Thesis.pdf

Hambali, E. (2007). Teknologi Bioenergi. PT. Agromedia Pustaka.

Hidayatulloh, D. (2018). Studi Numerik Pengaruh Variasi Suhu Udara Inlet Zona Oksidasi Pada Proses Gasifikasi Pelet Municipal Solid Waste Terhadap Karakteristik Reaktor Tipe Downdraft [Institut Teknologi Sepuluh Nopember]. https://repository.its.ac.id/56566/1/02111340000009-Undergraduate_Theses.pdf

Hou, S.-S., Huang, W.-C., Rizal, F. M., & Lin, T.-H. (2016). Co-Firing of Fast

KESDM. (2015). Potensi Energi Baru Terbarukan (EBT) Indonesia. Https://Www.Esdm.Go.Id/.

Louwes, A. C., Basile, L., Yukananto, R., Bhagwandas, J. C., Bramer, E. A., & Brem, G. (2017). Torrefied biomass as feed for fast pyrolysis: An experimental study and chain analysis. Biomass and Bioenergy, 105(1), 116–126. https://www.sciencedirect.com/science/article/pii/S0961953417301952

Pyrolysis Bio-Oil and Heavy Fuel Oil in a 300-kWth Furnace. Applied Science, 6(11), 1–11. https://www.mdpi.com/2076-3417/6/11/326/pdf

Sukarjo, H., Cahyono, M. S., & Wardoyo. (2014). Studi Pengaruh Suhu Proses dan Jenis Bahan terhadap Rendemen dan Nilai Kalor Bio-oil Hasil Pirolisis Sampah Organik. Laporan Penelitian Dosen Pemula Universitas Proklamasi 45 Yogyakarta.

Wibowo, S. (2013). Karakteristik Asap cair Serbuk Gergaji Sengon Menggunakan Proses Pirolisis Lambat. Jurnal Penelitian Hasil Hutan, 4.

Wilkomirsky, I., Moreno, E., & Berg, A. (2014). Bio-Oil Production from Biomass by Flash Pyrolysis in a Three-Stage Fluidized Bed Reactors System. Journal of Materials Science and Chemical Engineering, 1(1), 6–10. https://www.scirp.org/pdf/MSCE_2014012014283701.pdf

Yokoyama, S. (2008). Buku Panduan Biomassa Asia (Panduan untuk Produksi dan Pemanfaatan Biomassa). Japan Institute of Energy.

DOI: https://doi.org/10.20961/nozel.v4i1.72188

Refbacks

  • There are currently no refbacks.